基于非稳态热传导的SAGD开发指标预测模型

doi:10.12108/yxyqc.20230114

岩性油气藏 ›› 2023, Vol. 35 ›› Issue (1): 160–168.doi: 10.12108/yxyqc.20230114

• 石油工程与油气田开发 • 上一篇

基于非稳态热传导的SAGD开发指标预测模型

丁超¹, 王攀¹, 秦亚东², 梁向进¹, 郑爱萍¹, 李宁¹, 邢向荣¹

1. 中国石油新疆油田分公司, 新疆克拉玛依 834000;
2. 阿尔伯塔大学石油工程学院, 埃德蒙顿 T6 G1 H9

收稿日期:2022-04-11 修回日期:2022-06-08 出版日期:2023-01-01 发布日期:2023-01-06
第一作者:丁超(1982-),男,硕士,高级工程师,主要从事油田勘探开发技术方面的研究工作。地址:(834000)新疆克拉玛依市宝石路278号科研生产办公楼A座。Email:ptrdc@petrochina.com.cn
通信作者: 王攀(1987-),男,高级工程师,主要从事稠油SAGD开发技术方面的研究工作。Email:zy-wp@petrochina.com.cn。
基金资助:
国家油气重大科技专项“稠油/超稠油开发关键技术”(编号: 2016ZX05012)与中国石油天然气股份有限公司科技项目“稠油/超稠油开采关键技术”(编号: 2019B-14)联合资助

SAGD production performance prediction model based on unsteady heat transfer

DING Chao¹, WANG Pan¹, QIN Yadong², LIANG Xiangjin¹, ZHENG Aiping¹, LI Ning¹, XING Xiangrong¹

1. PetroChina Xinjiang Oilfield Company, Karamay 834000, Xinjiang, China;
2. Faculty of Petroleum Engineering, University of Alberta, Edmonton T6 G1 H9, Canada

Received:2022-04-11 Revised:2022-06-08 Online:2023-01-01 Published:2023-01-06

摘要/Abstract

摘要： 根据传热学和热采理论，利用程序设计的方法，对考虑边界效应的SAGD(蒸汽辅助重力泄油)非稳态热传导模型和开发关键指标解析解及开发指标的快速预测进行了研究。研究结果表明:①现有的非稳态热传导模型对传热外边界的温度假设存在局限性，根据能量守恒原理修正传热外边界条件，建立传热深度与累积传热量的解析关系，可定量计算上覆和下伏地层的热损失；②在巴特勒经典SAGD产量模型基础上，推导的蒸汽腔上升及横向扩展阶段和下压阶段的产水量、油汽比和蒸汽热利用率等解析模型，可实现SAGD特定开发阶段或全生命周期开发关键指标的快速预测；③通过与实际指标对比，井组生产6.4a预测油汽比和含水率的符合率均在95%以上，证实了解析模型和程序设计的可靠性；④根据准噶尔盆地风城油田重32井区油藏参数，预测分析的不同油层厚度条件下SAGD蒸汽热利用率和关键开发指标表明，蒸汽热利用率大于35%、油汽比大于0.15对应油层厚度应大于12m。

关键词: 非稳态传热, SAGD, 热损失, 蒸汽热利用率, 油汽比, 重32井区, 风城油田, 准噶尔盆地

Abstract: According to the theories of heat transfer and thermal recovery，the SAGD (steam-assisted gravity drainage) unsteady heat transfer model and the analytical solutions of key development indexes were derived， which were taken into account for boundary effect. The rapid prediction of development indexes was realized by using the program design method. The results show that: (1) The existing unsteady heat transfer models have limitations on the temperature assumption of the outer boundary of heat transfer. According to the principle of energy conservation，the outer boundary condition of heat transfer was modified，and the analytical relationship between the heat transfer depth and the accumulated heat transfer was established，which can be used to quantitatively calculate the heat loss of the overburden and underburden. (2) On the basis of Butler’s classical SAGD production model，the analytical models of water production，oil-steam ratio and steam heat utilization ratio in the steam chamber rising stage，lateral expansion stage and downward expansion stage were derived respectively，which can realize the rapid prediction of key indicators in the specific development stage or the whole life cycle of SAGD. (3) By comparing with the actual production indexes of the well group in 6.4 years，the coincidence rates of predicted oilsteam ratio and predicted water-cut are above 95%，which confirms the reliability of the analytical model and the program design. (4) According to the reservoir parameters of Zhong 32 well area in Fengcheng oilfield of Junggar Basin，the predicted and analyzed SAGD steam heat utilization rate and key development indicators under different oil layer thickness conditions show that when the steam heat utilization ratio is greater than 35% and the oilsteam ratio is greater than 0.15，the corresponding oil layer thickness should be greater than 12 m.

Key words: unsteady heat transfer, steam-assisted gravity drainage, heat loss, steam heat utilization ratio, oilsteam ratio, Zhong 32 well area, Fengcheng oilfield, Junggar Basin

中图分类号:

TE345

丁超, 王攀, 秦亚东, 梁向进, 郑爱萍, 李宁, 邢向荣. 基于非稳态热传导的SAGD开发指标预测模型[J]. 岩性油气藏, 2023, 35(1): 160–168.

DING Chao, WANG Pan, QIN Yadong, LIANG Xiangjin, ZHENG Aiping, LI Ning, XING Xiangrong. SAGD production performance prediction model based on unsteady heat transfer[J]. Lithologic Reservoirs, 2023, 35(1): 160–168.

参考文献

[1] BUTLER R M. A new approach to the modelling of steam-assisted gravity drainage[J]. Journal of Canadian Petroleum Technology, 1985,24 (3): 42-51.
[2] BULTER R M. Steam-assisted gravity drainage: Concept,development,performance and future[J]. Journal of Canadian Petroleum Technology,1994,33 (2): 44-50.
[3] 周明升. 超稠油蒸汽辅助重力泄油开发技术应用研究[D].大庆: 东北石油大学,2010: 30-38. ZHOU Mingsheng. Study on the application of steam assisted gravity drainage technology in the development of super heavy oil[D]. Daqing: Northeast Petroleum University,2010: 30-38.
[4] 王大为,刘小鸿,张风义,等. 各向异性稠油油藏SAGD产能公式校正[J].岩性油气藏,2014,26 (1): 123-126. WANG Dawei,LIU Xiaohong,ZHANG Fengyi,et al. Correction of SAGD productivity formula in anisotropic heavy oil reservoir[J]. Lithologic Reservoirs,2014,26 (1): 123-126.
[5] 孙新革. 浅层超稠油双水平井SAGD技术油藏工程优化研究与应用[D].南充: 西南石油大学,2012: 4-127. SUN Xinge. Reservoir engineering optimization research and application of SAGD technology in shallow super heavy oil dual horizontal wells[D]. Nanchong: Southwest Petroleum University, 2012: 4-127.
[6] 秦明. 蒸汽辅助重力泄油产量预测模型研究[D].成都: 西南石油大学,2016: 14-21. QIN Ming. Study on the production prediction model of steam assisted gravity drainage[D]. Chengdu: Southwest Petroleum University,2016: 14-21.
[7] 吴永彬,李秀峦,孙新革,等. 双水平井蒸汽辅助重力泄油注汽井筒关键参数预测模型[J]. 石油勘探与开发,2012,39 (4): 481-488. WU Yongbin,LI Xiuluan,SUN Xinge,et al. Key parameters forecast model for injector wellbores during the dual-well SAGD process[J]. Petroleum Exploration and Development,2012,39 (4): 481-488.
[8] 吴永彬,李秀峦,赵睿,等.双水平井SAGD循环预热连通判断新解析模型[J]. 西南石油大学学报 (自然科学版)，2016, 38 (1): 84-91. WU Yongbin,LI Xiuluan,ZHAO Rui,et al. A new analytical model of heat communication judgement during heat circulation phase of dual-horizontal SAGD[J]. Journal of Southwest Petroleum University (Science & Technology Edition)，2016,38 (1): 84-91.
[9] BUTLER R M. 重油和沥青的热力开采工艺[M]. 王秉璋,译. 北京: 石油工业出版社,1994: 54-65. Butler R M. Thermal recovery of oil and bitumen[M]. WANG Bingzhang,trans. Beijing: Petroleum Industry Press,1994: 54-65.
[10] SIAVASHI M,GARUSI H,DERAKHSHAN S. Numerical simulation and optimization of steam-assisted gravity drainage with temperature,rate,and well distance control using an efficient hybrid optimization technique[J]. Numerical Heat Transfer Applications,2017,72 (9): 1-24.
[11] SIVARAMKRISHNAN K,HUANG B,JANA A K. Predicting wellbore dynamics in a steam-assisted gravity drainage system: Numeric and semi-analytic model,and validation[J]. Applied Thermal Engineering,2015,91: 679-686.
[12] 于天忠,张建国,叶双江,等. 辽河油田曙一区杜84块超稠油油藏水平井热采开发技术研究[J]. 岩性油气藏,2011,23 (6): 114-119. YU Tianzhong,ZHANG Jianguo,YE Shuangjiang,et al. Development technology with thermal recovery for horizontal well of superheavy oil reservoir in Du 84 block in Shu 1 area,Liaohe Oilfield[J]. Lithologic Reservoirs,2011,23 (6): 114-119.
[13] PANG Zhanxi,WU Zhengbin,ZHAO Meng. A novel method to calculate consumption of non-condensate gas during steam assistant gravity drainage in heavy oil reservoirs[J]. Energy,2017, 130: 76-85.
[14] 田杰,刘慧卿,庞占喜,等. 高压环境双水平井SAGD三维物理模拟实验[J]. 石油学报,2017,38 (4): 95-102. TIAN Jie,LIU Huiqing,PANG Zhanxi,et al. Experiment of 3D physical simulation on dual horizontal well SAGD under high pressure condition[J]. Acta Petrolei Sinica,2017,38 (4): 95-102.
[15] 宫博识,文华国,李丛林,等. 准噶尔盆地乌尔禾地区风城组沉积环境分析[J]. 岩性油气藏,2014,26 (2): 59-66. GONG Boshi,WEN Huaguo,LI Conglin,et al. Sedimentary environment of Fengcheng Formation in Urho area,Junggar Basin[J]. Lithologic Reservoirs,2014,26 (2): 59-66.
[16] 杨帆,卞保力,刘慧颖,等. 玛湖凹陷二叠系夏子街组限制性湖盆扇三角洲沉积特征[J]. 岩性油气藏,2022,34 (5): 63-72. YANG Fan,BIAN Baoli,LIU Huiying,et al. Sedimentary characteristics of fan delta in restricted lacustrine basin of Permian Xiazijie Formation in Mahu Sag[J]. Lithologic Reservoirs,2022, 34 (5): 63-72.
[17] 冯有良,胡素云,李建忠,等. 准噶尔盆地西北缘同沉积构造坡折对层序建造和岩性油气藏富集带的控制[J]. 岩性油气藏,2018,30 (4): 14-25. FENG Youliang,HU Suyun,LI Jianzhong,et al. Controls of syndepotitional structural slope-break zones on sequence architecture and enrichment zones of lithologic reservoirs in northwestern margin of Junggar Basin[J]. Lithologic Reservoirs,2018, 30 (4): 14-25.
[18] CARSLAW H S,JAEGER J C. Conduction of heat in solids[M]. Oxford: Oxford Science Publications,1986.
[19] 杨世铭,陶文铨. 传热学[M]. 北京: 高等教育出版社,2006: 133-137. YANG Shiming,TAO Wenquan. Heat transfer[M]. Beijing: Higher Education Press,2006: 133-137.
[20] BUTLER R M,MCNAB G S,LO H Y. Theoretical studies on the gravity drainage of heavy oil during in-situ steam heating[J]. The Canadian Journal of Chemical Engineering,1981,59: 455-60.
[21] PINTO H,WANG X,GATES I. On the ratio of energy produced to energy injected in SAGD: Long-term consequences of early stage operational decisions[J]. Journal of Petroleum Science and Engineering,2021,199: 108271.

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed

基于非稳态热传导的SAGD开发指标预测模型

SAGD production performance prediction model based on unsteady heat transfer

PDF (PC)

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

Metrics

本文评价

推荐阅读 10

[1]	余琪祥, 罗宇, 段铁军, 李勇, 宋在超, 韦庆亮. 准噶尔盆地环东道海子凹陷侏罗系煤层气成藏条件及勘探方向[J]. 岩性油气藏, 2024, 36(6): 45-55.
[2]	白玉彬, 李梦瑶, 朱涛, 赵靖舟, 任海姣, 吴伟涛, 吴和源. 玛湖凹陷二叠系风城组烃源岩地球化学特征及页岩油“甜点”评价[J]. 岩性油气藏, 2024, 36(6): 110-121.
[3]	乔桐, 刘成林, 杨海波, 王义凤, 李剑, 田继先, 韩杨, 张景坤. 准噶尔盆地盆1井西凹陷侏罗系三工河组凝析气藏特征及成因机制[J]. 岩性油气藏, 2024, 36(6): 169-180.
[4]	李道清, 陈永波, 杨东, 李啸, 苏航, 周俊峰, 仇庭聪, 石小茜. 准噶尔盆地白家海凸起侏罗系西山窑组煤岩气“甜点”储层智能综合预测技术[J]. 岩性油气藏, 2024, 36(6): 23-35.
[5]	魏成林, 张凤奇, 江青春, 鲁雪松, 刘刚, 卫延召, 李树博, 蒋文龙. 准噶尔盆地阜康凹陷东部深层二叠系超压形成机制及演化特征[J]. 岩性油气藏, 2024, 36(5): 167-177.
[6]	杨海波, 冯德浩, 杨小艺, 郭文建, 韩杨, 苏加佳, 杨皩, 刘成林. 准噶尔盆地东道海子凹陷二叠系平地泉组烃源岩特征及热演化史模拟[J]. 岩性油气藏, 2024, 36(5): 156-166.
[7]	卞保力, 刘海磊, 蒋文龙, 王学勇, 丁修建. 准噶尔盆地盆1井西凹陷石炭系火山岩凝析气藏的发现与勘探启示[J]. 岩性油气藏, 2024, 36(3): 96-105.
[8]	王天海, 许多年, 吴涛, 关新, 谢再波, 陶辉飞. 准噶尔盆地沙湾凹陷三叠系百口泉组沉积相展布特征及沉积模式[J]. 岩性油气藏, 2024, 36(1): 98-110.
[9]	尹路, 许多年, 乐幸福, 齐雯, 张继娟. 准噶尔盆地玛湖凹陷三叠系百口泉组储层特征及油气成藏规律[J]. 岩性油气藏, 2024, 36(1): 59-68.
[10]	李二庭, 米巨磊, 张宇, 潘越扬, 迪丽达尔·肉孜, 王海静, 高秀伟. 准噶尔盆地东道海子凹陷二叠系平地泉组烃源岩特征[J]. 岩性油气藏, 2024, 36(1): 88-97.
[11]	杨兆臣, 卢迎波, 杨果, 黄纯, 弋大琳, 贾嵩, 吴永彬, 王桂庆. 中深层稠油水平井前置CO₂蓄能压裂技术[J]. 岩性油气藏, 2024, 36(1): 178-184.
[12]	王金铎, 曾治平, 徐冰冰, 李超, 刘德志, 范婕, 李松涛, 张增宝. 准噶尔盆地沙湾凹陷二叠系上乌尔禾组流体相态及油气藏类型[J]. 岩性油气藏, 2024, 36(1): 23-31.
[13]	赵长虹, 孙新革, 卢迎波, 王丽, 胡鹏程, 邢向荣, 王桂庆. 薄层超稠油驱泄复合开发蒸汽腔演变物理模拟实验[J]. 岩性油气藏, 2023, 35(5): 161-168.
[14]	聂礼尚, 马静辉, 唐小飞, 杨智, 张婉金, 李鸿蕊. 准噶尔盆地东部帐篷沟地区中新生代构造事件及其油气地质意义[J]. 岩性油气藏, 2023, 35(5): 81-91.
[15]	刘国勇, 许多年, 胡婷婷, 潘树新, 潘拓, 王国栋, 马永平, 关新. 准噶尔盆地沙湾凹陷侏罗系八道湾组滩砂的发现及石油地质意义[J]. 岩性油气藏, 2023, 35(5): 1-10.